DOC AIRBUS | AMM A320FDisinsection of the Aircraft Equipment and Furnishings
TASK 12-21-12-670-002-A
Disinsection of the Aircraft Equipment and Furnishings
Self Explanatory
2. Job Set-up Information
A. Fixtures, Tools, Test and Support Equipment
B. Consumable Materials
C. Work Zones and Access Panels
D. Referenced Information
3. Job Set-up
Subtask 12-21-12-861-053-A Subtask 12-21-12-865-054-A
Subtask 12-21-12-615-051-A
Subtask 12-21-12-865-055-A
[Rev.10 from 2021]
2026.04.01 03:56:53 UTC
Disinsection of the Aircraft Equipment and Furnishings
WARNING:
MAKE SURE THAT ONLY THE PERSONS THAT ARE NECESSARY TO DO THIS TASK ARE IN THE AIRCRAFT DURING THIS PROCEDURE.
WARNING:
BE CAREFUL WHEN YOU USE CONSUMABLE MATERIALS. OBEY THE MATERIAL MANUFACTURER'S INSTRUCTIONS AND YOUR LOCAL REGULATIONS.
1. Reason for the JobSelf Explanatory
2. Job Set-up Information
A. Fixtures, Tools, Test and Support Equipment
| REFERENCE | QTY | DESIGNATION |
|---|---|---|
| No specific | 1 | SAFETY BARRIER(S) |
| No specific | AR | SAFETY CLIP - CIRCUIT BREAKER |
| No specific | 1 | WARNING NOTICE(S) |
| REFERENCE | DESIGNATION |
|---|---|
| (Material No.11ABB2) | Disinfectant-Aircraft in flight cabin Insecticide - |
| (Material No.11ACB1) | Disinfectant-Aircraft Long term treatment Insecticide - |
| (Material No.14SBA1) | Textile-Lint free Cotton - |
| ZONE/ACCESS | ZONE DESCRIPTION |
|---|---|
| 100 | LOWER HALF FUSELAGE INCLUDING RADOME |
| 200 | UPPER HALF FUSELAGE |
| REFERENCE | DESIGNATION |
|---|---|
| TASK 12-21-12-100-001-A | Cleaning of the Cockpit Display-Units |
| TASK 12-21-12-100-002-A | Cleaning of the Cockpit Equipment/Furnishings |
| TASK 12-21-12-100-004-A | Cleaning of the Cabin Surfaces and Mirrors |
| TASK 12-21-12-100-006-A | Cleaning of the Light Alloy and Steel Components |
| TASK 12-21-12-100-008-A | Cleaning of the Cabin Monitors and Display Screens (if installed) |
| TASK 12-33-21-618-001-A | Pre-conditioning through the LP Ground Connection (Aircraft Electrical Power Available) |
| TASK 12-33-21-618-001-A-01 | Pre-conditioning through the HP Ground Connection |
| TASK 12-33-21-618-001-A-02 | Pre-conditioning with the APU |
| TASK 12-33-21-618-001-A-03 | Pre-conditioning through the LP Ground Connection (Aircraft Electrical Power Not Available) |
| TASK 24-42-00-861-001-A | Energize the Ground Service Network from the External Power |
| TASK 24-42-00-862-001-A | De-energize the Ground Service Network Supplied from the External Power |
| TASK 52-10-00-010-001-A | Opening of the Passenger/Crew Door |
| TASK 52-10-00-410-001-A | Closing of the Passenger/Crew Door |
| TASK 52-30-00-860-001-A | Open the FWD or Aft Cargo-Compartment Door with the Yellow Electric Pump |
| TASK 52-30-00-860-002-A | Close the FWD or Aft Cargo-Compartment Door with the Yellow Electric Pump |
Subtask 12-21-12-861-053-A Subtask 12-21-12-865-054-A
B. Open, safety and tag this(these) circuit breaker(s):
Subtask 12-21-12-010-052-A | PANEL | DESIGNATION | FIN | LOCATION |
|---|---|---|---|
| ** ON A/C ALL | |||
| 122VU | ELEC/GALLEY/CNTOR | 7MC | S28 |
| 122VU | ELEC/GALY & CAB/CTL | 1XA | S26 |
| ** ON A/C NOT FOR ALL | |||
| 2000VU | VACUUM CLEANER SKT-CAB-Z222 | 1ME | F07 |
| ** ON A/C NOT FOR ALL | |||
| 2000VU | VACU CLEANER SKT-CAB-Z222 | 1ME | F07 |
| ** ON A/C NOT FOR ALL | |||
| 2000VU | VACU CLEANER SKT-CAB-Z222 | 1ME | A03 |
| ** ON A/C NOT FOR ALL | |||
| 2001VU | LAV SHAVER SOCKET | 1MT | B01 |
| ** ON A/C ALL | |||
| 2001VU | VACU CLEANER SKT-CAB-Z261 | 5ME | F06 |
C. Get Access
(1) Put the WARNING NOTICE(S) in position to tell your personnel about the aircraft disinsectization.
(2) Disinsectization is necessary for these compartment volumes:
(6) If the trap-door 231AF is installed:
(a) Open the trap-door.
(b) Put a SAFETY BARRIER(S) around the open trap-door.
(c) Put a WARNING NOTICE(S) in position to tell your personnel that the trap-door 231AF is open.
(8) Open the forward and aft cargo-compartment doors (Ref. AMM TASK 52-30-00-860-001).
4. Procedure(1) Put the WARNING NOTICE(S) in position to tell your personnel about the aircraft disinsectization.
(2) Disinsectization is necessary for these compartment volumes:
| ---------------- Compartment | Aircraft Model --------------- A318 | Aircraft Model -------------- A319 | Aircraft Model -------------- A320 | Aircraft Model -------------- A321 |
|---|---|---|---|---|
| Cockpit | 9 m3 (318 ft.3) | 9 m3 (318 ft.3) | 9 m3 (318 ft.3) | 9 m3 (318 ft.3) |
| Cabin (SEE NOTE) | 80 m3 (3178 ft.3) | 95 m3 (3355 ft.3) | 110 m3 (3885 ft.3) | 137 m3 (4838 ft.3) |
| Forward Cargo | 6.5 m3 (230 ft.3) | 10.7 m3 (378 ft.3) | 15.5 m3 (547 ft.3) | 25.4 m3 (897 ft.3) |
| Aft and Bulk Cargo | 14.7 m3 (519 ft.3) | 21.2 m3 (749 ft.3) | 28 m3 (989 ft.3) | 32.6 m3 (1151 ft.3) |
NOTE: The volumes are calculated with all the compartment furnishings installed.
(3) Open the FWD passenger/crew door (Ref. AMM TASK 52-10-00-010-001). NOTE: All other passenger/crew doors must be closed.
(4) If necessary, remove the cushions and backrests of the cabin seats, the cockpit seats and the cabin attendant seats. NOTE: We recommend that you remove all of the cushions and backrests. The insecticide soaks into these materials and increases the ventilation time after disinsectization.
(5) Open all the stowages, the lavatory doors and the cockpit door. (6) If the trap-door 231AF is installed:
(a) Open the trap-door.
(b) Put a SAFETY BARRIER(S) around the open trap-door.
(c) Put a WARNING NOTICE(S) in position to tell your personnel that the trap-door 231AF is open.
WARNING:
MAKE SURE THAT THE SAFETY DEVICES AND THE WARNING NOTICES ARE IN POSITION WHEN THE TRAP DOOR (231AF) IS OPEN.
INJURY CAN OCCUR IF PERSONS FALL THROUGH THE OPENING.
(7) Remove the loose items of furnishing and equipment from all compartments. (8) Open the forward and aft cargo-compartment doors (Ref. AMM TASK 52-30-00-860-001).
Subtask 12-21-12-615-051-A
A. Disinsectization of the Aircraft
(a) Apply
Disinfectant-Aircraft Long term treatment Insecticide - (Material No.11ACB1)
or
Disinfectant-Aircraft in flight cabin Insecticide - (Material No.11ABB2) to the:
(2) Disinsect the cargo compartments:
(a) Apply
Disinfectant-Aircraft Long term treatment Insecticide - (Material No.11ACB1)
or
Disinfectant-Aircraft in flight cabin Insecticide - (Material No.11ABB2)
to the cargo compartments.
(b) Close the forward and aft cargo-compartment doors (Ref. AMM TASK 52-30-00-860-002).
(3) Keep all the aircraft doors closed for 45 minutes.
(4) Obey the material manufacturer's instructions and the local regulations to do the ground air pre-conditioning to remove the insecticide from the cabin and the cockpit (Ref. AMM TASK 12-33-21-618-001).
(5) Open all the passenger/crew doors (Ref. AMM TASK 52-10-00-010-001).
(6) Clean all the surfaces of the cockpit and the cabin:
5. Close-upWARNING:
MAKE SURE THAT ONLY THE PERSONS THAT ARE NECESSARY TO DO THIS TASK ARE IN THE AIRCRAFT DURING THIS PROCEDURE.
WARNING:
DO NOT LET DISINFECTANTS GO ONTO FOODSTUFFS. DISINFECTANTS ARE POISONOUS. DO NOT SPRAY THEM DIRECTLY ONTO CARPETS OR COCKPIT INSTRUMENT PANELS. DISINFECTANTS CAN CAUSE DAMAGE TO FURNISHINGS AND EQUIPMENT.
(1) Disinsect the cockpit and cabin area: (a) Apply
Disinfectant-Aircraft Long term treatment Insecticide - (Material No.11ACB1)
or
Disinfectant-Aircraft in flight cabin Insecticide - (Material No.11ABB2) to the:
- Floor area of the cockpit
- Floor of the galleys and the lavatories
- Floor adjacent to the galleys and lavatories
- Cabin area.
(2) Disinsect the cargo compartments:
(a) Apply
Disinfectant-Aircraft Long term treatment Insecticide - (Material No.11ACB1)
or
Disinfectant-Aircraft in flight cabin Insecticide - (Material No.11ABB2)
to the cargo compartments.
(b) Close the forward and aft cargo-compartment doors (Ref. AMM TASK 52-30-00-860-002).
(3) Keep all the aircraft doors closed for 45 minutes.
(4) Obey the material manufacturer's instructions and the local regulations to do the ground air pre-conditioning to remove the insecticide from the cabin and the cockpit (Ref. AMM TASK 12-33-21-618-001).
(5) Open all the passenger/crew doors (Ref. AMM TASK 52-10-00-010-001).
(6) Clean all the surfaces of the cockpit and the cabin:
- The cockpit display units
(Ref. AMM TASK 12-21-12-100-001) - The cockpit equipment and furnishings
(Ref. AMM TASK 12-21-12-100-002) - The plastic surfaces and mirrors
(Ref. AMM TASK 12-21-12-100-004) - The light alloy and steel components
(Ref. AMM TASK 12-21-12-100-006) - The monitors and display screens in the cabin
(Ref. AMM TASK 12-21-12-100-008).
Subtask 12-21-12-865-055-A
A. Remove the safety clip(s) and the tag(s) and close this(these) circuit breaker(s):
Subtask 12-21-12-410-052-A | PANEL | DESIGNATION | FIN | LOCATION |
|---|---|---|---|
| ** ON A/C ALL | |||
| 122VU | ELEC/GALLEY/CNTOR | 7MC | S28 |
| 122VU | ELEC/GALY & CAB/CTL | 1XA | S26 |
| ** ON A/C NOT FOR ALL | |||
| 2000VU | VACUUM CLEANER SKT-CAB-Z222 | 1ME | F07 |
| ** ON A/C NOT FOR ALL | |||
| 2000VU | VACU CLEANER SKT-CAB-Z222 | 1ME | F07 |
| ** ON A/C NOT FOR ALL | |||
| 2000VU | VACU CLEANER SKT-CAB-Z222 | 1ME | A03 |
| ** ON A/C NOT FOR ALL | |||
| 2001VU | LAV SHAVER SOCKET | 1MT | B01 |
| ** ON A/C ALL | |||
| 2001VU | VACU CLEANER SKT-CAB-Z261 | 5ME | F06 |
B. Close Access
(1) If removed, install the cushions and the backrests of the cabin seats, the cockpit seats and the cabin attendant seats.
(2) Put back the loose items of furnishing and equipment in all compartments.
(3) Make sure that the work area is clean and clear of tools and other items.
(4) Close all the stowages, the lavatory doors and the cockpit door (and the trap-door 231AF if installed).
(5) Remove the safety barrier.
(6) Close all the passenger/crew doors (Ref. AMM TASK 52-10-00-410-001).
(7) Remove the WARNING NOTICE(S).
(8) Remove the ground support and maintenance equipment, the special and standard tools and all other items.
Subtask 12-21-12-862-053-A (1) If removed, install the cushions and the backrests of the cabin seats, the cockpit seats and the cabin attendant seats.
(2) Put back the loose items of furnishing and equipment in all compartments.
(3) Make sure that the work area is clean and clear of tools and other items.
(4) Close all the stowages, the lavatory doors and the cockpit door (and the trap-door 231AF if installed).
(5) Remove the safety barrier.
(6) Close all the passenger/crew doors (Ref. AMM TASK 52-10-00-410-001).
(7) Remove the WARNING NOTICE(S).
(8) Remove the ground support and maintenance equipment, the special and standard tools and all other items.