Removal of the ACT Air Shut-Off Valve

TASK 28-28-36-000-001-A
Removal of the ACT Air Shut-Off Valve

WARNING: BE CAREFUL NOT TO GET AIRCRAFT FUEL IN YOUR MOUTH OR IN YOUR EYES. IF YOU GET FUEL ON YOUR SKIN OR ON YOUR CLOTHES, FLUSH IT IMMEDIATELY WITH WATER. IF NECESSARY, GET MEDICAL HELP. AIRCRAFT FUEL IS POISONOUS.

WARNING: DO NOT GET YOUR CLOTHES SOAKED WITH FUEL.

WARNING: MAKE SURE THAT YOU HAVE THE CORRECT FIRE FIGHTING EQUIPMENT AVAILABLE.

WARNING: OBEY THE FUEL SAFETY PROCEDURES.

FIN: 168QM ** ON A/C NOT FOR ALL

1. Reason for the Job
Self explanatory
2. Job Set-up Information
A. Fixtures, Tools, Test and Support Equipment

REFERENCE	QTY	DESIGNATION
No specific	AR	PLUG - BLANKING
No specific	AR	SAFETY CLIP - CIRCUIT BREAKER
No specific	1	WARNING NOTICE(S)

B. Referenced Information

REFERENCE	DESIGNATION
TASK 24-42-00-861-001-A	Energize the Ground Service Network from the External Power
TASK 28-00-00-910-001-A	Fuel Safety Procedures
TASK 28-28-56-000-001-A	Removal of the ACT Air Shut-Off Valve Actuator
ACT Air Shut-off Valve

3. Job Set-up
Subtask 28-28-36-860-050-A ** ON A/C NOT FOR ALL

A. Aircraft Maintenance Configuration
(1) Obey the fuel safety procedures (Ref. AMM TASK 28-00-00-910-001).
(2) Energize the ground service network
(Ref. AMM TASK 24-42-00-861-001).
(3) Put a WARNING NOTICE(S) in position:

the refuel/defuel panel 801VU,
the fuel panel 40VU,
to tell persons not to operate the refuel/defuel system.

Subtask 28-28-36-010-051-A ** ON A/C NOT FOR ALL

B. Get Access
(1) Remove the Actuator of the Air Shut-Off Valve (Ref. AMM TASK 28-28-56-000-001).

Subtask 28-28-36-865-050-A ** ON A/C NOT FOR ALL

C. Open, safety and tag this(these) circuit breaker(s):

PANEL	DESIGNATION	FIN	LOCATION
** ON A/C NOT FOR ALL
121VU	ACT1/REFUEL & SPLY	33QU	L29
121VU	FUEL/HI/LVL/SPLY	1QJ	L25
121VU	FUEL/RFL/DFL/SPLY	2QU	L24
121VU	FUEL/RFL/DFL/XFR/DEFUEL/VALVE	1QU	L23
121VU	ACT XFR VALVE MAN CTL	30QH	N29
121VU	ACT1/CTL & SPLY	9QH	P29
121VU	ACT PUMP SUPPLY	25QH	Q29

4. Procedure
Subtask 28-28-36-020-050-A ** ON A/C NOT FOR ALL

A. Removal of the Air Shut-Off Valve
(1) Loosen the union nuts (3) and (5) from the ports (2) and (9) of the air shut-off valve (1).
(2) Remove the nuts (6) and the washers (7) from the studs (4).
(3) Remove the air shut-off valve (1) from the attachment bracket (8).
(4) Put the PLUG-BLANKING in each disconnected line end.

[Rev.10 from 2021] 2026.04.02 06:17:56 UTC